De meningen ge-uit door medewerkers en studenten van de TU Delft en de commentaren die zijn gegeven reflecteren niet perse de mening(en) van de TU Delft. De TU Delft is dan ook niet verantwoordelijk voor de inhoud van hetgeen op de TU Delft weblogs zichtbaar is. Wel vindt de TU Delft het belangrijk - en ook waarde toevoegend - dat medewerkers en studenten op deze, door de TU Delft gefaciliteerde, omgeving hun mening kunnen geven.

Can we stop Deepwater Horizon becoming an unprecedented environmental disaster?

This article was also published on Reuters The Great Debate UK on May 14th 2010, titled How much damage will the BP oil spill cause?

Kees Willemse, Professor of Offshore Engineering, Delft University of Technology

Last month’s explosion at the Deepwater Horizon rig continues to result in the leakage of an estimated 200,000 gallons of oil into the Gulf of Mexico each day.  According to US President Barack Obama, ‘we are dealing with a massive and potentially unprecedented environmental disaster’.

While the leak is extremely serious, and Obama’s words may ultimately ring true, the leak is (as yet) not one of the top 50 biggest oil spillages from either oil rigs or tankers in historical perspective:
•    Some 7-10,000 tonnes of oil are so far estimated to have leaked into the Gulf of Mexico from Deepwater Horizon.
•    The Exxon Valdez leaked some 36.000 tonnes of crude oil on the shores of Alaska.
•    The largest ever off-shore leakage of oil occurred in 1979 in the Ixtoc-1 spillage when an estimated 476,000 tonnes of oil polluted the Gulf of Mexico (Bay of Campeche).
•    The biggest ever on-shore spillage occurred in the aftermath of the 1991 Iraq War when an estimated 1.4 to 1.5 million tonnes was released in Kuwait by Iraqi military forces.

Most at risk from the Deepwater Horizon spill are the coastlines of Texas, Florida, Mississippi, Alabama, and Louisiana, including the wetlands near New Orleans where millions of migratory birds are currently nesting, and fish spawning.  The oil spill could also be catastrophic for the Gulf Coast’s substantial seafood industry, including oysters and shrimp.

To mitigate the environmental impact, measures will continue to be taken to prevent as much of the oil as possible reaching the shoreline, including setting fires to ‘burn-off’ the oil; soaking up the oil; and placing protective ‘barriers’ around shorelines.   

The precise scale of the unfolding disaster remains uncertain owing to the lack of clarity over how long the leak will last.  In the worst-case scenario, as US Interior Secretary Ken Salazar has suggested, the leak could continue for several more months.  Uncertainty is also increased by the fact that BP executives are reported to have admitted to members of the US Congress that the amount of oil spilling could intensify — perhaps by several multiples of the current leakage per day — if they cannot cap the flow.

Hopes for a relatively early end to the leakage are resting largely upon the success of the operation to install a five-storey, 100 tonne containment dome.  The device was to be lowered by cranes around 1500 metres to the sea floor and, if possible, positioned over the two areas of leaking pipe.  If successful, the dome would serve as a giant funnel, collecting and piping it for collection on the sea surface. However, this operation has only been applied at a much smaller water depth and the first attempt to employ the device here has not been successful.
Even if successful, the dome will not stem all of the leakage (perhaps 80-90% of it) and there remains a risk of explosion when the oil reaches the surface because of the volatile mix of oil, gas and water.  Thus, the operation can only be a ‘holding’ one to buy time until the spillage can be shut off at the two remaining sources of the leak.  

While shutting off the leakage at source will be an immensely difficult task, hopes will have been raised last week by the fact that BP successfully shut off the smallest of the three original leakages.  This was done by placing a valve over the ruptured pipe and shutting it off using a remotely controlled submarine.  

The best hope of shutting off the two remaining sources of leakage is getting the blow-out preventor working again.  This is the system, which should act as an emergency cut-off to stop oil continually spilling out if a pipe is damaged, and which failed catastrophically last month.

The Deepwater Horizon blow-out preventor is proving immensely hard to fix, in large part because of the exceptional depth of the water.  Robot submarines are attempting to re-start the system, albeit without success to date.

In the event that the blow-out preventor cannot be fixed, relief wells have begun to be drilled that could be used to siphon off the oil leaking from the holed pipeline. This operation will take an estimated two to three months as the drilling is taking place at 1500 metres water depth and a further 5 kilometres into the hard rock. The relief well can also be drilled such that the shaft of the new well enters into the shaft of the existing, problematic well. A cement prop can then be inserted to stop the flow in the first well. This requires extremely accurate drilling, but that technique has been proven before.

Inevitably, all of this environmental mitigation and emergency replacement activity is proving extremely expensive. The cost to BP alone is an estimated 6 million dollars a day, and independent estimates have put the final bill at between 3 billion and 12 billion dollars.  However, the effects of this accident cannot be expressed in money terms alone, because of the growing scale of the environmental disaster if the oil spill cannot be contained soon.  

Once the crisis is over, industry and government will need to make an in-depth analysis of the cause of the accident to ensure that similar incidents can never happen again.  And Delft University of Technology is ready to mobilise its resources to join this effort and provide the technological support that will be required to make offshore activities safe for the generations to come.

Be Sociable, Share!

1 comment

If its not a blow by or fear for a blow by, its rather simple to replace the so called failing BOP. 20 years ago I presented my company a concept of an equipment to replace a failing BOP. Any way, 27 years ago I presented the oil majors a concept for oil drilling, cheaper, faster and safer. Most major advances in oil drilling of the last 25 years were included in that concept. So to my opinion the oil spill is a result of rather clumsy operations. best regards, JvdVeen

Leave a Reply

© 2011 TU Delft